2016 Mitsubishi Outlander Recalls: 8 Safety Recalls
NHTSA lists 8 safety recalls for the 2016 Mitsubishi Outlander. Here's what each one means for a used-car buyer.
8
Open recall campaigns (NHTSA)
No
“Park it” urgent warning
6
Vehicle systems affected
Get the full Buyer Brief for your 2016 Mitsubishi Outlander
Enter the VIN and we'll pull this car's exact open recalls, a fair market-value range, an inspection checklist, and a 5-point negotiation script — in about 30 seconds.
Run my VIN report — $9.99
Open recalls for the 2016 Mitsubishi Outlander
ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
NHTSA 17V609000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2015-2017 Outlander, 2015-2016 Lancer and Outlander Sport, and 2015 Lancer Evolution vehicles. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.
Risk: If the engine stalls, there is an increased the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the affected relays, free of charge. The recall began October 24, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-005.
Reported: 29/09/2017
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
NHTSA 17V233000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The inside door latch mechanisms may not latch securely in high temperatures, allowing the doors to open while vehicle is in motion.
Risk: If a door opens while the vehicle is being driven, it can increase the risk of injury.
Remedy: MMNA will notify owners, and dealers will replace the door latches, free of charge. The recall began August 25, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-002.
Reported: 06/04/2017
PARKING BRAKE
NHTSA 18V070000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2016 Outlander and 2013-2016 Outlander Sport vehicles. Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind.
Risk: If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will inspect the rear brake calipers and replace the parking brake boot and lever or the brake caliper body, as necessary. Dealers will also replace the piston assembly of the rear brake caliper. These repairs will be performed free of charge. The recall is e…
Reported: 26/01/2018
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
NHTSA 16V563000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2015-2016 Outlander Sport vehicles and 2016 Outlander and Lancer vehicles. The affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle accelerating.
Risk: A hesitation during acceleration can increase the risk of a crash.
Remedy: MMNA has notified owners, and dealers will reprogram the CVT control unit with modified software, free of charge. The recall began on August 15, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-006.
Reported: 28/07/2016
SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY
NHTSA 20V403000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2019 Outlander and 2018-2019 Outlander PHEV vehicles. The second-row center seat belt buckle may interfere with the right-side seat belt buckle when the seat backs are folded down. The interference may cause the right-side seat belt buckle cover to come off, making the buckle latch inoperable and unable to restrain an occupant.
Risk: An unrestrained occupant has an increased risk of injury in the event of a crash.
Remedy: MMNA will notify owners, and dealers will modify the second-row center seat belt buckle cover, install a new warning label to the second-row seat support base, and provide a new warning label insert for the owner's manual, free of charge. The recall began September 1, 2020. Owners may contact MMN…
Reported: 13/07/2020
PARKING BRAKE
NHTSA 20V741000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process. As a result, water entering the rear brake caliper boot may cause the parking brake operating shafts to corrode and possibly bind.
Risk: If the parking brake operating shafts bind, the parking brakes may not engage or disengage fully. If the parking brakes do not engage properly, the vehicle could rollaway, increasing the risk of a crash.
Remedy: MMNA will notify owners, and dealers will replace the rear brake caliper assemblies, free of charge. Owner letters were mailed May 4, 2021. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-005.
Reported: 30/11/2020
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
NHTSA 25V507000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles sold and/or currently registered in Alaska, Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, North Dakota, Nebraska, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Sout…
Risk: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
Remedy: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters were mailed October 6, 2025. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-25-002
Reported: 07/08/2025
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
NHTSA 26V252000
Defect: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018-2022 Outlander PHEV and 2014-2020 Outlander vehicles. The liftgate gas spring cylinders may corrode and lose pressure, which can result in a gas spring cylinder rupture or the liftgate falling unexpectedly.
Risk: A gas spring cylinder rupture or a liftgate falling unexpectedly can increase the risk of injury.
Remedy: MMNA will replace the left and right liftgate gas springs, free of charge. Owner notification letters are expected to be mailed June 17, 2026. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-26-001. Vehicle Identification Numbers (VINs) involved in t…
Reported: 20/04/2026
Is the 2016 Mitsubishi Outlander safe to buy used?
8 open recalls doesn't automatically mean you should walk away — most recalls are repaired free of charge at a dealer. What matters is whether this specific car has had the work done. An unrepaired recall is both a safety risk and real negotiating leverage: you can make the repair a condition of sale or ask for money off to cover your time.
How buyers use recall data to negotiate
- Lead with the facts. Bring the NHTSA campaign numbers to the seller — it signals you've done your homework.
- Make repair a condition. Ask the seller to complete any open recall at a dealer before you pay.
- Trade it for price. If they won't fix it, ask for money off to cover the trip and downtime.
- Verify the VIN. A full ClearVIN Buyer Brief confirms which recalls are still open on the exact car.
Get the full Buyer Brief for your 2016 Mitsubishi Outlander
Enter the VIN and we'll pull this car's exact open recalls, a fair market-value range, an inspection checklist, and a 5-point negotiation script — in about 30 seconds.
Run my VIN report — $9.99
Frequently asked questions
How many recalls does the 2016 Mitsubishi Outlander have?
NHTSA lists 8 open safety recalls for the 2016 Mitsubishi Outlander. Each campaign and its remedy is listed above.
Are Mitsubishi Outlander recall repairs free?
Yes. Safety recall repairs are performed free of charge at any authorized Mitsubishi dealer, regardless of the car's age or mileage and regardless of how many owners it has had.
How do I check if a specific 2016 Mitsubishi Outlander had its recalls fixed?
You need the car's 17-character VIN. A ClearVIN Buyer Brief looks up the exact VIN against NHTSA's database and shows which recall campaigns are still open on that individual vehicle.
Should recalls stop me from buying a used 2016 Mitsubishi Outlander?
Not necessarily. Most recalls are quick, free dealer fixes. Use any open recall as leverage: ask the seller to complete the repair before sale, or negotiate the price down to cover it.
Other Mitsubishi Outlander model years